OATEY -- OATEY LO-VOC PURPLE PRIMER NSF, 31894  -- 8040-00N083515
<pre>=====================  Product Identification  =====================

Product ID:OATEY LO-VOC PURPLE PRIMER NSF, 31894
MSDS Date:01/01/1996
FSC:8040
NIIN:00N083515
=== Responsible Party ===
Company Name:OATEY
Address:4700 WEST 160TH ST
Box:35906
City:CLEVELAND
State:OH
ZIP:44135
Country:US
Info Phone Num:216-267-7100
Emergency Phone Num:303-623-5716;800-424-9300(CHEMTREC)
CAGE:IO629
=== Contractor Identification ===
Company Name:OATEY
Address:4700 W 160TH ST
Box:35096
City:CLEVELAND
State:OH
ZIP:44135
Country:US
Phone:303-623-5716
CAGE:IO629
Company Name:OATEY CO
Address:4700 WEST 160TH STREET
Box:35906
City:CLEVELAND
State:OH
ZIP:44135
Country:US
Phone:216-267-7100/303-623-5716
CAGE:53472

=============  Composition/Information on Ingredients  =============

Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 70-80%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:CYCLOHEXANONE (CERCLA)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 12-16%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (CERCLA)
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 10-15%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 250 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 1-5%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:ANTHRAQUINONE, 1-HYDROXY-4-(P-TOLUIDINO)-; (VIOLET DYE)
CAS:81-48-1
RTECS #:CB7700000
Fraction by Wt: <1%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:C.I. SOLVENT RED 26; (RED DYE)
CAS:4477-79-6
Fraction by Wt: <1%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:VOLATILE ORGANIC COMPOUND: 70-80% WT
RTECS #:9999999VO
OSHA PEL:N/K 
ACGIH TLV:N/K 

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:INHAL: MAY CAUSE IRRITATION OF MUCOUS
    MEMBRANES, NOSE AND THROAT, HEADACHE, DIZZINESS, NAUSEA, NUMBNESS
    OF EXTREMITIES AND NARCOSIS IN HIGH CONCS. HAS CAUSED CNS DEPRESS
    AND LIVER DAMAGE IN ANIMALS AN D CONCENTRATIONS OF 1000-3000 PPM
    CAUSERETARDATION OF FETAL DEVELOPMENT IN RATS. EYE: VAPOR OR DIRECT
    (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CONTACT MAY CAUSE IRRITATION. INGEST:
    MAY BE ASPIRATED INTO LUNGS OR CAUSE SYSTEMIC EFFECTS DESCRIBED
    UNDER INHAL. SKIN: CHRONIC CONTACT MAY LEAD TO IRRITATION AND
    DERMATITIS. CHRONIC EXPOSU RE TO VAPORS OF HIGH CONC MAY CAUSE
    DERMATITIS. MAY POSSIBLY BE ABSORBED THRU SKIN. TARGET ORGANS: EYE,
    SKIN, LUNG, CNS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:SKIN: FLUSH W/WATER THEN WASH THOROUGHLY W/SOAP AND WATER.
    REMOVE CONTAMINATED CLOTHING AND WASH BEFORE REUSE. CALL POISON
    CONTROL CENTER OR MD IF IRRITATION PERSISTS. EYES: FLUSH W/WATER
    FOR AT LEAST  15 MINUTES AND CALL POISON CONTROL CENTER OR MD IF
    IRRITATION PERSISTS. INHAL: MOVE TO FRESH AIR. IF BREATHING IS
    DIFFICULT, GIVE OXYGEN. IF NOT BREATHING, GIVE ARTIFICIAL
    RESPIRATION. KEEP (SUPDAT)

=====================  Fire Fighting Measures  =====================

Flash Point Method:PMCC
Flash Point:>0F,>-18C
Lower Limits:1.8%
Upper Limits:11.8%
Extinguishing Media:FOR SMALL FIRES: USE DRY CHEMICAL, CARBON DIOXIDE,
    WATER OR FOAM EXTINGUISHER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
    EQUIPMENT . FOR LARGE FIRES, EVACUATE AREA AND CALL FIRE DEPARTMENT
    IMMEDIATELY.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

==================  Accidental Release Measures  ==================

Spill Release Procedures:VENTILATE AREA, STOP LEAK IF IT CAN BE DONE
    WITHOUT RISK. TAKE UP WITH SAND, EARTH OR OTHER NON-COMBUSTIBLE
    ABSORBING MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
    FLAMES; STORE IN COOL, DRY PLACE.
Other Precautions:CONTAINERS, EVEN EMPTIES WILL RETAIN RESIDUE AND
    VAPORS.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH APPROVED CANNISTER RESPIRATOR IN ABSENCE
    OF ADEQUATE VENTILATION.
Ventilation:GENERAL MECHANICAL: EXHAUST VENT CAPABLE OF MAINTAINING
    EMISSIONS AT POINT OF USE BELOW PEL. LOCAL EXHAUST: (SUPDAT)
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: VICTIM QUIET & WARM. CAL POIS CONTROL CENTER OR MD
    IMMED. INGEST: DRINK WATER & CAL POISON CONTROL CENTER OR MD IMMED.
    AVOID ALCOHOLIC BEVERAGES. NEVER GIVE ANYTHING BY MOUTH TO AN UNC
    ON PERSON. DO NOT INDUCE VOMITING. VENT: OPEN DOORS AND WINDOWS. IF
    USED IN ENCLOSED AREA, USE EXHAUST FANS.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:151F,66C
Vapor Pres:145 @ 20C
Vapor Density:2.5
Spec Gravity:0.94   0.01
Evaporation Rate &amp; Reference:5.5-8.0 (BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID; ETHER-LIKE ODOR.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATLS, ALKALIS, CHLORINATED INORGS (POTASSIUM, CALCIUM
    & SODIUM HYPOCHLORITE), COPPER OR COPPER ALLOYS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE/CARBON
    DIOXIDE/HYDROGEN CHLORIDE/SMOKE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
    REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.